1990 volvo 240 stall out after 10 minutes

[ignatz]

Hi! Am trying to figure out a problem on a 90 Volvo 240 with auto trans
starts well but always stalls after about 10 minutes. You must wait abou
10-15 minutes before it will start- then will again stall in 10 minute
like clockwork. Engine sounds good when it is running. I know these car
pretty well, but have never encountered this - any ideas are appreciated
thanx, bo

-
Message posted using http://www.talkaboutautos.com/group/alt.autos.volvo
More information at http://www.talkaboutautos.com/faq.htm

 

[JSR]

I had a 1980 240 with the same symptoms (ish), turned out to be the
ignition coil. It was fine for a while, then once it got too warm it
failed (the car would stutter, hesitate and stall), I could pull the car
to the side wait 10 minutes and it would be good again for a while.

 

[clay]

Hi! Am trying to figure out a problem on a 90 Volvo 240 with auto trans -
starts well but always stalls after about 10 minutes. You must wait about
10-15 minutes before it will start- then will again stall in 10 minutes
like clockwork. Engine sounds good when it is running. I know these cars
pretty well, but have never encountered this - any ideas are appreciated.
thanx, bob

I had a similar issue with an old Chevy. Turned out there was a screen
(more like a sock actually) on the fuel pickup in the tank. It was
crudded up so it would collapse and block fuel flow. After it sat for a
while, the screen would expand and allow more fuel in the line. Took a
lot of parts swapping (and a complete engine rebuild... don't get me
started on that one) before I figured that one out.

Don't know if 240s have a screen on the fuel pickup, I've never had the
tank out of my '83.

 

[ignatz]

Thanks for the great info so far - bo

-
Message posted using http://www.talkaboutautos.com/group/alt.autos.volvo
More information at http://www.talkaboutautos.com/faq.htm

 

[Mr. V]

There is a screen on the pickup, it presses on and certainly could get
fouled over time.