1991 240 Automatic Transmission leak

All was going well with my lovely 240 (US) untill the past week. Sure
I was leaking the quart of trans fluid every two weeks or so. But, in
the last week the fluid has come gushing out of it-3 qts a day and hits
the exhaust creating horrific smoke . It leaks like there is no end.
Surely, there is, like the end of the trans.

I see it dripping off a metal line from directly below. I have resigned
myself to the worse case scenario-that is- a used or rebuilt trans.

Okay, I guess I have a shop check for leakage source?

Also, how do I know if the trans has the notch for the crank sensor or
not unless it is removed form the car first?

Advance thanks

 

Check the transmission cooler lines where they mount to the engine there
is a small bracket that they are held in onto remove the hold down
bracket & you will mostlikly see that the steel line is worn away there
you can replace the lines or just remove the worn section of line &
replace with a section of fuel line
Glenn

--
"*-344-*Never Forgotten"
Is for the New York City Firemen who lost their lives on September 11,2001.
The official count is 343, but there was also a volunteer who lost his life
aiding in the initial rescue efforts. And I will never forget them as
long as I live,
nor should any American.

 

Sounds like the cooling line has cracked, it tends to happen right near
where it bolts to the frame under the car. I fixed one of these once by
cutting out the cracked section, flaring the ends and patching in a
piece of power steering hose.

 

Speedometer still working?
(if it's similar to my '83...) then another place to look is the speedo
drive where it attaches to the tranny. Mine broke off (thanks to a
broken tranny mount) and dumped fluid.
ymmv.

 

Not in a '91, they went to an electronic rear axle speedo in '86.