AM Radio Reception in S60R

  • Thread starter Thread starter Mark Rayner
  • Start date Start date
M

Mark Rayner

Does anyone else have poor AM Radio reception in S60's.

I have a '04 S60R and it's really poor. If anyone has encounted the problem
or fixed it, I'd appreciate your thoughts.



Cheers,



Mark
 
Mark said:
Does anyone else have poor AM Radio reception in S60's.

I have a '04 S60R and it's really poor. If anyone has encounted the problem
or fixed it, I'd appreciate your thoughts.



Cheers,



Mark
Click to expand...

Good luck we're working on the same problem with many cars.
 
Good luck we're working on the same problem with many cars.
Click to expand...

In the past there was antenna tuning adjustment at the rear of the radio near
where the coaxial antenna cable enters the radio. The procedure is to tune
the radio to a weak station at the bottom end of the band (550KHz) and adjust
it for maximum signal. I do not know if newer radios come with this
necessity.



Regards,

Boris Mohar

Got Knock? - see:
Viatrack Printed Circuit Designs (among other things) http://www.viatrack.ca

void _-void-_ in the obvious place
 
Does anyone else have poor AM Radio reception in S60's.

I have a '04 S60R and it's really poor. If anyone has encounted the problem
or fixed it, I'd appreciate your thoughts.

Cheers,

Mark
Click to expand...

Ditto here. Isn't the antennae in the windshied?
p.
 
Mark said:
Does anyone else have poor AM Radio reception in S60's.

I have a '04 S60R and it's really poor. If anyone has encounted the problem
or fixed it, I'd appreciate your thoughts.



Cheers,



Mark
Click to expand...
There is a tech note about this 39-35 this usually solves the am problem
I would send the tech note but my isp does not allow it to be sent
Glenn

--
"*-344-*Never Forgotten"
Is for the New York City Firemen who lost their lives on September 11,2001.
The official count is 343, but there was also a volunteer who lost his life
aiding in the initial rescue efforts. And I will never forget them as
long as I live,
nor should any American.
 
There is a tech note about this 39-35 this usually solves the am problem
I would send the tech note but my isp does not allow it to be sent
Glenn
Click to expand...

Can yo send it using this?
http://s10.yousendit.com/

I would not mind seeing it either.




Regards,

Boris Mohar

Got Knock? - see:
Viatrack Printed Circuit Designs (among other things) http://www.viatrack.ca

void _-void-_ in the obvious place
 
Boris Mohar said:
Can yo send it using this?
http://s10.yousendit.com/

I would not mind seeing it either.
Click to expand...

8mm [5/16²]

45 deg

NO: 39-35

DATE: 04/03/2003

MODEL/YEAR: S80 MY 99 à, S60 MY 01 à

SUBJECT: Poor AM Reception

CHASSIS:

REFERENCE: Service Bulletin 39-0018 and 39-0025

DESCRIPTION:

Cases have been reported in which AM static will increase and maintain a
higher level, resulting in

complaints of poor AM reception. The increase in AM static may be triggered
by several reasons,

including: bumps in the road, closing the doors. The AM static will stop by
several reasons, including:

Central Door Lock activation, rear defrost activation, touching the trim
covering the antenna amplifier.

SERVICE:

It has been determine the increase in AM static is due to a loose connection
between the antenna

amplifier and antenna cable. To improve the connection (and AM reception),
this Tech Net Note

provides instructions to install a brass strip, Part Number 30657370.

The brass strip must be bent as illustrated:

NOTE: It is critical not to exceed the 8 mm (5/16") length. If this length
is exceeded, it will result is

worse reception.

Tech-Net Notes

"Fixed Right - First Time"

Volvo Technicians, Service and Parts Managers

Install the brass strip into the antenna amplifier as illustrated:

Install antenna cable so that the locking clips are not on top of the brass
strip. It may help to push the

locking clips to help seat properly.

NOTE: After the antenna cable has been installed, pull the antenna cable to
verify the locking clips are

holding the antenna cable in the proper position. If the antenna cable
releases easily, the locking clips

were not seated.

Picture of antenna amplifier after brass strip has been installed:

Tape used

to secure

brass strip

Brass strip

Locking clips

(push at this

point and on

opposite

side to help

seat locking

clip)

Bend brass strip

to curve at base

of connector

8mm [5/16²] (do not exceed this length)

Apply tape to

secure brass strip

WARRANTY CLAIM INFORMATION

LABOR OP LABOR DESCRIPTION LABOR TIME

99042-2 Antenna Amplifier 1 side modifying S60 0.3 hr

S80 0.6 hr

Claims may be submitted under the New Car warranty when there is a
documented customer complaint using claim type: 01

VOLVO for life,

Volvo Cars of North America, LLC.

Technical Service

Please read, initial and circulate:

____Svc Mgr ____ Parts Mgr ____ ____ ____ ____ ____ ____ ____ ____ ____ ____
____ TECHS

____Wty Administrator
 
Glenn said:
There is a tech note about this 39-35 this usually solves the am problem
I would send the tech note but my isp does not allow it to be sent
Glenn

--
"*-344-*Never Forgotten"
Is for the New York City Firemen who lost their lives on September 11,2001.
The official count is 343, but there was also a volunteer who lost his life
aiding in the initial rescue efforts. And I will never forget them as > long as I live,
nor should any American.
Click to expand...

I would like to have a copy, too. What type of file is it that is not
allowed (or is it too big)? If it is just the file type you can change the
type (such as 39-35.pdf to 39-35.pd_ and then you can send it.

Thanks Glenn,

Allen
 
Mark said:
Does anyone else have poor AM Radio reception in S60's.

I have a '04 S60R and it's really poor. If anyone has encounted the problem
or fixed it, I'd appreciate your thoughts.



Cheers,



Mark
Click to expand...
http://download.yousendit.com/D5D71B8030B8AFF4
hope this helps all
Glenn

--
"*-344-*Never Forgotten"
Is for the New York City Firemen who lost their lives on September 11,2001.
The official count is 343, but there was also a volunteer who lost his life
aiding in the initial rescue efforts. And I will never forget them as
long as I live,
nor should any American.
 
Glenn

That is brilliant help, thank you. My car runs out of warranty early next
year, so I will now have the ammunition I need in case they don't want to do
anything about it!

Thanks again Glenn very much appreciated.


Mark
 
Glenn said:
http://download.yousendit.com/D5D71B8030B8AFF4
hope this helps all
Glenn

--
"*-344-*Never Forgotten"
Is for the New York City Firemen who lost their lives on September 11,2001.
The official count is 343, but there was also a volunteer who lost his life
aiding in the initial rescue efforts. And I will never forget them as
long as I live,
nor should any American.
Click to expand...

Thank you Glenn, perfect!

Allen
 
You must log in or register to reply here.
Back
Top