Wiring diagrams for 240?

[Patrick Keenan]

Hello,
I have a 1992 240 wagon. Recently, had ignition problems that appear to
have been the air flow mass meter - a substitute has been swapped in and
it's running fine. Except...

Also had some service done to the tailgate. Now, when I switch on the
tailgate wiper switch, the top fuse burns, also taking out the radio. I
stopped by the garage and the tailgate wiper motor, which has apparently
seized, was disconnected... but the problem still occurs. Also, when I
touch the brake, the Lamp Failure cluster light comes on - and so does the
bulb for the tailgate defroster switch. It was too bright to notice this
one earlier.

I'll be taking the car back to the garage for this and some other work next
week, but in the meantime, does anyone know where I can find wiring
diagrams? I think I can fix this in some of the spare time I will have
while out of town this weekend, and diagrams would help.

Thanks!
Patrick Keenan

 

[zencraps]

The best, clearest, most accurate and detailed wiring diagrams I have
found (and photocopied) are from the Mitchell Repair Manuals in the
public library.

 

[Mike F]

The best, clearest, most accurate and detailed wiring diagrams I have
found (and photocopied) are from the Mitchell Repair Manuals in the
public library.

Sounds like a problem in the wiring in the tailgate hinges. The wires
have to bend over 90 degrees in a very short area every time the
tailgate opens. The crack in this location inside the hinges. There's
been thousands of posts covering this topic over the years.

--
Mike F.
Thornhill (near Toronto), Ont.

Replace tt with t (twice!) and remove parentheses to email me directly.
(But I check the newsgroup more often than this email address.)

 

[Joe D]

I'll be taking the car back to the garage for this and some other work next
week, but in the meantime, does anyone know where I can find wiring
diagrams?

Suggest you give this site a visit.

https://www.volvotechinfo.com/index.cfm?event=item.serviceparts

Click on 1992 on the 240 line and then on service manuals and drill
down to find the "Volvo" green book - TP31953/1.

While a bit on the pricey side, they are the most descriptive.

Joe D.

 

[Patrick Keenan]

Sounds like a problem in the wiring in the tailgate hinges. The wires
have to bend over 90 degrees in a very short area every time the
tailgate opens. The crack in this location inside the hinges. There's
been thousands of posts covering this topic over the years.

Yes, this has been replaced - that was the work done to the tailgate. Both
the passenger's side hinge and the harnesses were replaced. And thanks -
I will look in that area for the short. Discovered this morning that the
light failure bulb goes off if I turn the Right-hand turn signal on.

Thanks again,
Patrick Keenan

 

[Patrick Keenan]

Suggest you give this site a visit.

https://www.volvotechinfo.com/index.cfm?event=item.serviceparts

Click on 1992 on the 240 line and then on service manuals and drill
down to find the "Volvo" green book - TP31953/1.

While a bit on the pricey side, they are the most descriptive.

Joe D.

Thanks, that may be exactly what I'm ultimately looking for. I had most of
a set of the green Volvo manuals for my old 220, and that's the level of
detail I am looking for.

Patrick Keenan

 

[Johan Plane]

Yes, this has been replaced - that was the work done to the tailgate. Both
the passenger's side hinge and the harnesses were replaced. And thanks -
I will look in that area for the short. Discovered this morning that the
light failure bulb goes off if I turn the Right-hand turn signal on.

Thanks again,
Patrick Keenan

To me, this sounds like a grounding fault.